Journal of Water and Wastewater; Ab va Fazilab (in persian)

Journal of Water and Wastewater; Ab va Fazilab (in persian)

Experimental and Numerical Investigation of a Novel Ultraviolet Water Disinfection Reactor withExternal Lamps

Articles in Press

Document Type : Research Paper

Authors
Seyed Mahdi Safavi 1
Amirhossein Hassanpour 2
Alireza Jalali 3
1 MSc. Student, School of Mechanical Engineering, University of Tehran, Tehran, Iran
2 PhD. Student, School of Mechanical Engineering, University of Tehran, Tehran, Iran
3 Assoc. Prof., School of Mechanical Engineering, University of Tehran, Tehran, Iran
10.22093/wwj.2026.592599.3567
Abstract
Ultraviolet disinfection serves as a safe physical method that generates no chemical by-products, making it a highly desirable alternative to traditional water treatment processes. However, conventional submerged reactors encounter severe operational challenges such as significant pressure drops along the fluid path. This study presents the first physical fabrication and comprehensive validation of a novel UV photoreactor featuring a fully segregated architecture. In this configuration, a central quartz water channel is accompanied by two mercury radiation sources situated in the surrounding air and outside the fluid domain. A concentric cylindrical reflector encloses this entire assembly. This specific design optimally reflects the omnidirectional radiation emitted by the mercury lamps back into the fluid domain. To develop a deeper understanding of the transport phenomena, computational fluid dynamics simulations were conducted. These simulations simultaneously integrated flow hydrodynamics, the discrete ordinates radiation model, and first-order inactivation kinetics. To validate the developed model, an experimental setup was constructed and subjected to biodosimetry testing utilizing Escherichia coli (strain ATCC 8739). The implementation of a thermal management mechanism based on forced convection stabilized the lamp surface temperature at an optimal 36.3 degrees Celsius. This stabilization ensured the consistency of the radiant power output. Microbial evaluations revealed that at the maximum operational flow rate of 27.5 liters per minute, the experimental log reduction value was 3.48. This value demonstrates excellent agreement with the calculated numerical value of 3.29. At lower flow rates of 21.7 and 17.6 LPM, complete pathogen inactivation was achieved, exceeding the laboratory detection limit. The numerical model predicted LRVs of 4.10 and 4.93 for these flow rates, respectively. These findings demonstrate that the synergy between direct and reflected radiation significantly enhances the uniformity of the radiation dose. The successful alignment of experimental and numerical data confirms that this segregated reactor design offers a new paradigm for developing efficient and economical water treatment systems with minimal maintenance requirements.
Keywords
Ultraviolet Water Disinfection
Computational Fluid Dynamics
Decoupled Photoreactor
Biodosimetry
Cylindrical Reflector
Adeoba, M. I., Odjegba, E. E. and Pandelani, T., 2024. Nature-Based Solutions: Opportunities and Challenges for Water Treatment, In Ayeleru, O. O., Idris, A. O., Olubambi, P. A., Eds. Smart Nanomaterials for Environmental Applications. Chapter 23. Elsevier, pp. 575-596. https://doi.org/10.1016/B978-0-443-21794-4.00011-9.
Albolafio, S., Marin, A., Allende, A., Garcia, F., Simon-Andreu, P. J., Soler, M. A. et al., 2022. Strategies for mitigating chlorinated disinfection byproducts in wastewater treatment plants. Chemosphere, 288, 132583. https://doi.org/10.1016/j.chemosphere.2021.132583.
Andersson, B., Andersson, R., Håkansson, L., Mortensen, M., Sudiyo, R. and Wachem, B. V., 2012. Turbulent Mixing and Chemical Reactions, In Andersson, B., Andersson, R., Håkansson, L., Mortensen, M., Sudiyo, R., Wachem, B. V., Eds. Computational Fluid Dynamics for Engineers. Chapter 5. Cambridge University Press, Wiley. pp. 113-142. https://doi.org/10.1017/cbo9781139093590.006.
Celik, I. B., Ghia, U., Roache, P. J., Freitas, C. J., Coleman, H. and Raad, P. E., 2008. Procedure for estimation and reporting of uncertainty due to discretization in CFD applications. Journal of Fluids Engineering, Transactions of The ASME, 130(7), 0780011-0780014. https://doi.org/10.1115/1.2960953.
Green, A., Popović, V., Pierscianowski, J., Biancaniello, M., Warriner, K. and Koutchma, T., 2018. Inactivation of Escherichia Coli, Listeria and Salmonella by single and multiple wavelength ultraviolet-light emitting diodes. Innovative Food Science and Emerging Technologies, 47, 353-361. https://doi.org/10.1016/j.ifset.2018.03.019.
Hassanpour, A., Jalali, A., Raisee, M. and Naghavi, M. R., 2023. Development and modeling of a novel type of photoreactors with exterior ultraviolet (UV) reflector for water treatment applications. Scientific Reports, 13(1), 7696. https://doi.org/10.1038/s41598-023-34799-0.
Heidarinejad, G., Bozorgmehr, N. and Safarzadeh, M., 2020. Effect of highly reflective material on the performance of water ultraviolet disinfection reactor. Journal of Water Process Engineering, 36, 101375. https://doi.org/10.1016/j.jwpe.2020.101375.
Kang, S., Bae, J., Park, S., Kim, K., Lee, J., Yoon, C. et al., 2024. Design optimization of a cylindrical UV-C LED reactor for effective water disinfection with numerical simulations and test reactor fabrication. Journal of Environmental Chemical Engineering, 12(2), 112366. https://doi.org/10.1016/j.jece.2024.112366.
Li, W., Li, M., Bolton, J. R., Qu, J. and Qiang, Z., 2017. Impact of inner-wall reflection on UV reactor performance as evaluated by using computational fluid dynamics: the role of diffuse reflection. Water Research, 109, 382-388. https://doi.org/10.1016/j.watres.2016.11.068.
Moghaddam, S., 2025. Numerical simulation and comparison of four different UVC-LED reactor models for point-of-use water disinfection using computational fluid dynamics. Journal of Water and Wastewater, 36(1), 74-96. (In Persian). https://doi.org/10.22093/wwj.2025.517963.3484.
Moghaddam, S., Asadi, M. and Khalili, K., 2024. Investigating the effect of UVC-LED reactor configurations on liquid foods disinfection using computational fluid dynamics. Journal of Environmental Chemical Engineering, 12(2), 112138. https://doi.org/10.1016/j.jece.2024.112138.
Rezaei, B., Rahmani, F. and Khamforoush, M., 2025. Toward efficient solar-driven photocatalytic treatment of water contaminated with various antibiotics using a porous BiOBr (2D)/UiO-66 (0D) heterojunction nanostructure. Journal of Water and Wastewater, 36(2), 23-42. (In Persian).  https://doi.org/10.22093/wwj.2025.535808.3502.
Rezaei, M., 2026. Water culture. Journal of Water and Wastewater, 36(5), 106-125.  (In Persian). https://doi.org/10.22093/wwj.2026.584459.3556.
Peleato, N. M., 2022. Application of convolutional neural networks for prediction of disinfection by-products. Scientific Reports, 12(1), 612. https://doi.org/10.1038/s41598-021-03881-w.
Pourtalebi, B., Alizadeh, R. and Abdoli, S. M., 2025. Recent advances in industrial photoreactors: a review from design to large-scale applications. Journal of Water Process Engineering, 77, 108619. https://doi.org/10.1016/j.jwpe.2025.108619.
Sanz, E. N., Dávila, I. S., Balao, J. A. and Alonso, J. Q., 2007. Modelling of reactivation after UV disinfection: effect of UV-C dose on subsequent photoreactivation and dark repair. Water Research, 41(14), 3141-3151. https://doi.org/10.1016/j.watres.2007.04.008.
Seyedin, M., Hassanpour, A., Jalali, A. and Raisee, M., 2024. Robust optimization of a novel ultraviolet (UV) photoreactor for water disinfection: a neural network approach. Chemosphere, 362, 142788. https://doi.org/10.1016/j.chemosphere.2024.142788.
Sobhani, H. and Shokouhmand, H., 2017. Effects of number of low-pressure ultraviolet lamps on disinfection performance of a water reactor. Journal of Water Process Engineering, 20, 97-105. https://doi.org/10.1016/j.jwpe.2017.08.021.
Song, J. J. X. and Oguma, K., 2024. UV-LED-incorporated showerhead for point-of-use disinfection of drinking water. Journal of Environmental Chemical Engineering, 12(6), 114573. https://doi.org/10.1016/j.jece.2024.1 14573.
Song, K., Mohseni, M. and Taghipour, F., 2016. Application of ultraviolet light-emitting diodes (UV-LEDs) for water disinfection: a review. Water Research, 94, 341-349. https://doi.org/10.1016/j.watres.2016.03.003.
Sozzi, D. A. and Taghipour, F., 2006. UV reactor performance modeling by Eulerian and Lagrangian methods. Environmental Science and Technology, 40(5), 1609-1615. https://doi.org/10.1021/es051006x.
Tsitsifli, S. and Kanakoudis, V., 2018. Disinfection impacts to drinking water safety-a review. Proceedings, 2(11), 603. https://doi.org/10.3390/proceedings2110603.
Wang, C. P., Wu, Y. L. and Yang, S. H., 2023. Effect of channel configuration on the water sterilization efficiency of a photoreactor with ultraviolet C light-emitting diodes. Process Safety and Environmental Protection, 179, 618-627. https://doi.org/10.1016/j.psep.2023.09.040.
Wols, B. A., Harmsen, D. J. H., Van Remmen, T., Beerendonk, E. F. and Hofman-Caris, C. H. M., 2015. Design aspects of UV/H2O2 reactors. Chemical Engineering Science, 137, 712-721. https://doi.org/10.1016/j.ces.2015.06.061.
Journal of Water and Wastewater; Ab va Fazilab (in persian)

Articles in Press, Accepted Manuscript
Available Online from 12 May 2026